PpTuning

▶

▶ 474 ❤ 0 💬 0

In with us today was this beauty but what is it

▶

▶ 5.8K ❤ 0 💬 0

Another VW T4 in with us for a full underbody restoration, with the customer wanting it done properly so it’ll need minimal maintenance going forward 👌 Last photo as it came in ⸻ 🔩 Full Strip Down Included: Exhaust system, mounts & rubbers Heat shields Fuel tank straps Underbody wiring loom (unclipped, not removed) Spare wheel & carrier Tow bar Wheels Front & rear brake shields Engine under-tray …basically everything needed to gain full access ⸻ 🧼 Cleaning & Preparation Using a combination of chemical, mechanical, and laser cleaning, we strip everything back — removing dirt, grime, and any loose/flaky previous coatings. Chassis grommets are removed ready for full internal wax/oil injection later on. ⸻ 🛠️ Treatment & Coating Any areas needing extra attention (rust removal etc.) are dealt with properly — not covered up. We then apply a tintable polyurethane chassis coating, with this one finished in VW Tornado Red 🔴 ⸻ 🔧 Reassembly & Finishing All removed components are cleaned, restored, and refitted. ✔ New stainless steel fastenings used where possible ✔ New brake shields fitted (painted & sealed) ✔ Brake calipers painted Once fully built back up, we apply two coats of hot wax for long-term protection. ⸻ 💥 The Result A properly restored and protected underside — built to last, not just look good. (See photos above 👆) ⸻ 🧪 Products Used: Bilt Hamber S50 Dynax UC Electrox Hydrate 80 Lanoguard Dinitrol RC900

▶

▶ 2.3K ❤ 0 💬 0

🔥 Something a bit different in the workshop… 🔥 We’ve had this slammed VW Caddy in for a proper custom job — and it’s safe to say, it’s turned a few heads already 👀 Instead of the usual setup, we’ve gone for a side-exit exhaust through the bumper… and honestly… how cool is this?! 😮‍🔥 It’s these one-off touches that really set a build apart. Subtle? Not quite. Stylish? Absolutely. Would you run this on your own van, or is it a bit too out there? Let us know 👇 #VWCaddy #CustomExhaust #pptuningexhaust #ModifiedVans #slammedcaddy fileciteturn0file0